Portable Test Interface (PTI) cables
FDR Interface Cables
RSU (PTI) Cables
Avionica’s portable test interface (PTI) cables enable connection to a number of flight data recorders (FDR) for retrieve of flight data. Cables are offered that enable connections to systems from the following FDR suppliers.
Universal Avionics Systems Corporation
802-0032 Universal CVFDR PTI Cable Kit
Portable Test Interface (PTI) for Universal Avionics Systems Corporation flight data recorders. Provides on-aircraft monitoring and data transcription capability for UASC model flight data recorders to RSU memory for subsequent translation and analysis. Interface mates to UASC CVFDR connector.
Base
802-0145 RSU BASE SCR-500 PTI Cable Kit & 802-0168 RSU BASE MCR-500 PTI Cable Adapter Kit (requires 802-0145)
BASE™ SCR 500 PTI. Provides on-aircraft real-time monitoring and data transcription from BASE™ SCR 500 series flight data recorders for subsequent translation and analysis. This interface also controls the voice recorder circuits of this combination voice-data recorder, and is therefore a pre-requisite when purchasing the BASE Audio Breakout Fixture (ABF), part number 802-0149. Transfers flight data at the rate of 100 times the record speed (100:1) for subsequent translation and analysis.
Boeing
802-0159 Boeing B737NG, B757, B767 Realtime PTI Cable Kit
Portable Test Interface (PTI) for Boeing 737, 757, 767 in-cockpit data monitoring. Provides on-aircraft real-time monitoring capability ONLY. Interface mates to standard aircraft mounted connector. Provides a convenient means of correlating pilot inputs and cockpit display data to DFDR recorded data. Note that not all 737 “legacy” aircraft are equipped with this connector.
802-0163 Boeing B717 Realtime PTI Cable Kit
Portable Test Interface (PTI) for Boeing 717 in-cockpit data monitoring. Provides on-aircraft real-time monitoring capability ONLY. Interface mates to standard aircraft mounted connector. Provides a convenient means of correlating pilot inputs and cockpit display data to DFDR recorded data.
embraer
802-0141 Embraer 120 Brasilia Realtime PTI Cable Kit
Portable Test Interface (PTI) for Boeing 737, 757, 767 in-cockpit data monitoring. Provides on-aircraft real-time monitoring capability ONLY. Interface mates to standard aircraft mounted connector. Provides a convenient means of correlating pilot inputs and cockpit display data to DFDR recorded data. Note that not all 737 “legacy” aircraft are equipped with this connector.
FDAMS
802-0160 RSU FDAMS/DMU PCMCIA PTI Kit
RSU Honeywell™ FDAMS™ PTI. Unlike most interfaces, this is not a cable. Instead it is a custom RSU cover which permits reading a PCMCIA memory card without opening the RSU cover. Some Honeywell flight data acquisition units record trend data on a removable PCMCIA flash memory card. Removing these cards from the aircraft places them at risk for damage, loss, or theft. To avoid this, use the RSU FDAMS™ card reader to read multiple cards without removing them from the aircraft, then transmit the data directly to your analysis system using the RSU and our WAN interface.
Honeywell
802-0173 Honeywell AR-FDR SSFDR PTI Cable Kit
Portable Test Interface (PTI) for Honeywell™ AR-FDR™ solid state, digital flight data recorders. Provides on-aircraft monitoring and data transcription capability to RSU memory for subsequent translation and analysis. Interface mates to front connector. Transcribes at 100 times recording speed (100:1).
802-0139 Honeywell (Sundstrand) DFDR Realtime PTI Cable Kit
Portable Test Interface (PTI) for Honeywell (Sundstrand) 981-6009-XXX Series DFDRs . Provides on-aircraft real-time monitoring capability ONLY. Interface mates to front connector. The design of this recorder precludes the ability to accomplish a readout without rack removal.
802-0130 Honeywell (Sundstrand) UFDR PTI Cable Kit
Portable Test Interface (PTI) for Honeywell (Sundstrand) digital flight data recorders. Provides on-aircraft monitoring and data transcription capability for model UFDR flight data recorders to RSU memory for subsequent translation and analysis. Interface mates to front connector. Transcribes at 12 times recording speed (12:1).
802-0146 Honeywell (Allied Signal) SSFDR PTI Cable Kit
Portable Test Interface (PTI) for Honeywell™ (Allied-Signal™) solid state, digital flight data recorders. Provides on-aircraft monitoring and data transcription capability to RSU memory for subsequent translation and analysis. Interface mates to front connector. Transcribes at 100 times recording speed (100:1).
L3 communications
802-0138 L3 Communications (Fairchild) F1000 PTI Cable Kit
RSU Portable Test Interface (PTI) for L3™ (Fairchild™) model F1000 flight data recorders. Provides on-aircraft monitoring and transcription capability to RSU memory for subsequent translation and analysis. Supports both ARINC 542A and ARINC 573/717 operating modes. Transcribes at 100 times recording speed (100:1). A complete transcription may be accomplished in just over 15 minutes. Resulting data file is L3 Proprietary .FDT file. L3 decompression software may be required (Avionica AVSCAN includes decompression utility).
802-0152 L3 Communications FA2100 PTI Cable Kit
Portable Test Interface (PTI) for L3™ model FA-2100 flight data recorders. Provides on-aircraft monitoring and data readout capability to RSU memory for subsequent translation and analysis. Supports ARINC 573/717 and 542 operating modes. Transcribes at up to 500 times recording speed (500:1). A complete transcription may be accomplished in approximately 5 minutes. Resulting data file is L3 Proprietary .FDT file. L3 decompression software may be required (Avionica AVSCAN includes decompression utility).
Lockheed
802-0137 Lockheed L-209 Portable Rack Adapter
Provides standard mating connector breakout for Avionica part number 650-0136 interface cable in cases where this connector has not been permanently installed in the aircraft bulkhead. Mounts between Lockheed™ model 209 flight data recorder and airframe connector to permit on-aircraft access to recorder data and control circuits without removal of recorder from aircraft (Lockheed™ model 209 units do not have a front connector). Monitor and transcribe your Lockheed™ units without costly re-certification expenses, and without the need for a permanent DFDR interface connection.
802-0136 Lockheed L-209/Plessey 1584 PTI Cable Kit
Provides on-aircraft monitoring and data readout capability for Lockheed™ model 209 flight data recorders, as well as Plessey DARU based systems. Transcribes at 120 times recording speed (120:1), completing a readout in an average of 18 minutes for subsequent transfer to analysis system. Generates ARINC-standard 12-bit packed raw binary data file.
Penney & Giles
802-0143 RSU Penney & Giles F50330 PTI Cable Kit
Provides on-aircraft monitoring and data readout capability for Penney & Giles™ model D50330 flight data recorders. Transcribes at up to 16 times recording speed (16:1)
802-0142 RSU Penney & Giles PTI Cable Kit
Provides on-aircraft monitoring and data readout capability for Penney & Giles model 91005 flight data recorders. Transcribes at up to 100 times recording speed (100:1)
Plessey
802-0162 Plessey PV-1584 Portable Rack Adapter
Provides standard mating connector breakout for Avionica part number 650-0136 interface cable in cases where this connector has not been permanently installed in the aircraft bulkhead. Mounts between Plessey™ model PV1584 series flight data recorder and airframe connector to permit on-aircraft access to recorder data and control circuits without removal of recorder from aircraft (Plessey™ PV1584 units do not have a front connector). Monitor and transcribe your Plessey™ units without costly re-certification expenses, and without the need for a permanent DFDR interface connection. Compatibility
Sagem
802-0164 RSU Sagem ED47F109 Realtime PTI Cable Kit
RSU Portable Test Interface (PTI) for Sagem™ Digital Flight Data Acquisition Unit (DFDAU) real-time data monitoring. Provides on-aircraft, real-time monitoring capability ONLY. Interface mates to standard DFDAU front-mounted connector. Provides a convenient means of correlating pilot inputs and cockpit display data to DFDAU output data.
SFIM
802-0150 RSU SFIM ESPAR PTI Cable Kit
SFIM™ (Sagem™) ESPAR™ PTI. Provides on-aircraft real-time monitoring and data transcription from SFIM ESPAR flight data recorders for subsequent transfer and translation on analysis system. Transcribes at 300 times recording speed (300:1).
Teledyne
802-0170 RSU Teledyne FDAU 2233000-8XX Realtime PTI Cable Kit
RSU Portable Test Interface (PTI) for Teledyne Controls Digital Flight Data Acquisition Unit (DFDAU) real-time data monitoring. Provides on-aircraft real-time monitoring capability ONLY. Interface mates to standard DFDAU front-mounted connector. Provides a convenient means of correlating pilot inputs and cockpit display data to DFDAU output data. Applicability
802-0154 RSU Teledyne FDAU 2222601 Realtime PTI Cable Kit
RSU Portable Test Interface (PTI) for Teledyne Controls™ Flight Data Acquisition Unit (FDAU) real-time data monitoring. Provides on-aircraft real-time monitoring capability ONLY. Interface mates to standard FDAU front-mounted connector. Provides a convenient means of correlating pilot inputs and cockpit display data to FDAU output data.
avionica
805-0005 Avionica miniQAR™ Mk II Support Utility
Avionica miniQAR™ Mk II Support Utility with High Speed USB 2.0 Interface Provides MS-Windows-based transcription capability for Avionica miniQAR™ Mk II series quick-access data recorders. Transcription is performed at a rate of up to 67 Mbytes per minute over USB 2.0 interface for subsequent analysis. The interface provides power TO the miniQAR, enabling it to be read on or off the aircraft, with or without power. Configurable to erase contents of miniQAR™ upon completion of a successful transcription. For use with a laptop, desktop, or tablet computer with an available USB 2.0 port. Platforms supported include Windows™ 2000, XP™, and 7 is supported.
805-0001 Avionica miniQAR™ Mk I Desktop Downloader
Avionica miniQAR™ MK I Desktop Interface. Provides transcription capability for Avionica miniQAR™ MK I series quick-access data recorders. Transcription is performed at a rate of up to 10 Mbytes per minute for subsequent analysis. The interface provides power TO the miniQAR, enabling it to be read on or off the aircraft, with or without power. Erases contents of miniQAR™ upon completion of a successful transcription. Must be used with a laptop or desktop computer with an available 9-pin serial port AND PS/2 keyboard connector. Platforms supported are Windows™ 98 and Windows™ NT4.0. There is currently no support for Windows™ 2000, XP™ or later.